Monthly Archives: February 2012

The Harm In Skipping An Oil Change For Huntington Beach Drivers

Posted on February 22, 2012 by gbroshb

People in Huntington Beach have been hearing a lot about higher oil change intervals these days. Maybe you’re wondering: What are the key issues?

Some new vehicle manufacturers in Huntington Beach are now recommending much higher oil change intervals than they have in the past. As much as 5,000 to 8,000 miles or more. This practice came under scrutiny when four of the largest new car manufacturers announced that owners like those in Huntington Beach were experiencing engine damage resulting from these higher oil change intervals.

The manufacturers’ standard oil drain service for particular vehicles was scheduled at around 7,500 miles. People following these recommendations were experiencing engine damage. It turns out that oil sludge was building up. This caused small oil passages to clog and engine parts to fail.

What causes oil sludge? It’s a factor of time and mileage. There are hot spots in every engine that cause oil burn off that leads to sludge. Also, water from normal condensation can build up in the oil. This water also creates sludge. Severe driving conditions lead to more rapid sludge formation.

Visit Gustafson Brothers in Huntington Beach, California 92648

Severe driving around Huntington Beach includes short trips under four miles or trips under ten miles in freezing conditions. The engine just doesn’t get warm enough for the water in the oil to evaporate.

Severe conditions are at the heart of the problem. Stop-and-go driving, towing, dusty conditions, heavy loads, very hot or very cold temperatures, a car top carrier – these are all conditions that would suggest that the severe service schedule should be considered.

The severe service schedule has much shorter oil change intervals. People in Huntington Beach just need to honestly evaluate how they drive to determine if they should change their oil closer to the severe service schedule, or to the standard schedule.

Some types of sedan will give oil change reminders. But it’s important to know how that reminder is determined. For some, the reminder simply comes when the standard mileage interval has rolled around. Others use a computer algorithm that takes into consideration the number of cold starts, trip length, engine temperature and so on. It’s programmed to approximate where on the standard/severe service spectrum you fall. Some more expensive vehicles actually have sensors that test the cleanliness and effectiveness of the oil.

For the rest of us, better safe than sorry should be the guiding principle. Talk with your Huntington Beach service advisor at Gustafson Brothers and work it out together. Find out what kind of oil the factory sends out in your vehicle. Sometimes it’s a premium grade that costs more than standard oil – but it may be what’s needed to meet a higher factory recommended interval.

If you’re realistically conservative, standard grades of oil will take care of you year after year. If you want to push the limits, ask for a premium grade oil to give you extra protection.

So, what happened with those manufacturers with the problems from higher oil change intervals? They ended up extending the engine warranty for parts that were affected by oil sludge. But they had a stipulation – they lowered the oil change interval and the vehicle owner had to provide proof of oil changes at the new lower interval to keep the extended warranty.

Share
Posted in Maintenance | Leave a comment

Wheel Bearings

Posted on February 15, 2012 by gbroshb

Let me start by saying that your wheel bearings keep the wheels on your vehicle. Did that get your attention? In this article we’ll discuss more about wheel bearings and how you can keep them doing their very important job while you drive around Costa Mesa California.

Come see us at: 19161 Gothard Street Huntington Beach, California 92648

Wheel bearings are pretty simple parts. They’re made of high quality steel and are engineered to last 100,000 miles or more if properly cared for. The bearings do two very important jobs: First they allow the wheel to freely rotate with as little friction as possible. Second, they support the weight of the vehicle. For example, if your car weighs 3,600 pounds, each wheel has to support approximately 900 pounds. That’s a lot of heavy lifting over many, many thousands of miles.

Even though wheel bearings are relatively simple, they need to be in near perfect condition to do their job. The bearings are packed with heavy grease to lubricate and protect them. A seal keeps the grease in and water and dirt out. It’s when the seal starts to leak that problems begin. The grease can become contaminated; causing the wheel bearings to overheat and ultimately fail.

The first sign that your wheel bearings are in trouble is an unusual noise coming from a wheel. It could be a chirping, growling, rumbling or a cyclic sound. The noise could get louder or even disappear at certain speeds. Your technician at Gustafson Brothers can inspect for bearing wear by lifting the vehicle and checking for play in the wheel.

Now some wheel bearing assemblies are factory sealed. That means that they cannot be serviced – they can only be replaced. Those that aren’t sealed can be serviced on schedule. The bearings are removed, cleaned and inspected. If the bearings are still good, they’re re-installed – if not, they’re replaced. They are then packed in grease and a new seal is installed.

If your vehicle has a factory sealed wheel bearing assembly, the entire assembly needs to be replaced when trouble arises. Unfortunately, the parts are pretty pricy – but they usually last about 150,000 miles as long as the seals hold up.

Now, even a good seal cannot keep out water that’s exerting pressure on the seal. So if you’ve driven through hub deep water your bearings should be cleaned and repacked if they’re serviceable. If you have factory sealed bearings, you just need to watch for signs of premature failure.

If your wheel bearings can be serviced, your owner’s manual will recommend an interval, usually around 30,000 miles.

Now, if you have any sort of trailer, don’t forget its wheel bearings. They probably need to be serviced even more frequently. This is especially true for boat trailers that are used to launch the boat by backing it into the water. These should be serviced every year, usually at the end of the season so that the bearings don’t have the opportunity to sit and rust all winter.

So what happens if wheel bearings fail? Well, the wheel can literally fall off the vehicle. I don’t need to tell you how bad that could be. So check with your service advisor at Gustafson Brothers and see if your vehicle’s wheel bearings can be serviced and when it’s recommended. Listen for warning signs. If you’ve been fording streams or puddle surfing after rainstorms, be especially vigilant.

Come by Gustafson Brothers for a wheel bearing inspection, or for preventative maintenance . Call for an appointment at 7148475600

Share
Posted in Tires and Wheels | Leave a comment

Huntington Beach Exhaust And Emissions Service

Posted on February 8, 2012 by gbroshb

Sometimes when we talk about exhaust service in Huntington Beach, we think about exhaust pipes and mufflers. And if you can see smoke, or if it’s too loud. But, exhaust service at a place like Gustafson Brothers is really a lot more comprehensive these days.

For example, in the U.S., the federal government mandated catalytic converters for all cars in Huntington Beach in 1976 and on-board emission control computers in 1990. California and federal emissions requirements have forced manufacturers to come up with much more sophisticated ways to comply with environmental regulations. Cars sold in Canada follow the same guidelines.

So, exhaust service has really become exhaust and emissions service. High-tech computer-controlled emissions devices are now a big part of that. And because it’s so sophisticated, your vehicle manufacturer recommends having your emission system checked out by a qualified technician, like the ones we have at Gustafson Brothers, regularly to make sure everything’s working right – which is usually every six months or 6,000 miles.

If your ‘check engine light’ comes on while you are driving around the Huntington Beach area, especially if it’s flashing, then you need to get your car looked at right away. Chances are it’s an emission related problem. You might have exhaust or emissions trouble if your car is hard to start, runs rough, or if it’s noisy or smoking.

So let’s review the exhaust system. Everything starts with the exhaust manifold. That’s the part that attaches to the engine and collects the exhaust from the cylinders and directs it into the exhaust pipe.

The exhaust gaskets help seal the connection with the manifold and other joints along the way. Now, if the manifold is cracked or loose, or a gasket is leaking, then dangerous gases could escape into the passenger compartment, where you ride. Carbon monoxide can be deadly, so it’s important that your exhaust system doesn’t leak.

The exhaust pipes connect the various components. They can rust or be damaged by a rock, so they need to be inspected periodically.

Next comes the catalytic converter. This part actually looks like a muffler. It changes chemicals that are dangerous to your health, and to the local California environment, into harmless carbon dioxide and water. Now it doesn’t require any maintenance itself. But eventually they wear out. If it has, you’ll probably find out when your car fails an emissions inspection.

Now the muffler. Its main job is to quiet engine noises. Mufflers work by either absorbing or baffling sound. And you can actually customize your car’s sound with different mufflers – which is pretty cool because you can change the look of your car, and the way it sounds.

Rusted or road-damaged mufflers can actually leak and they need to be replaced right away. The exhaust system is attached to the car by a series of hangers and clamps that hold the system in place. And when these hangers come loose or break then hot exhaust components can touch and melt wires, hoses and lines. Just think of the damage a hot curling iron can do – but worse. It’s not good to have that waving around.

And finally, we end at the tailpipe. Appropriate name. This is the final outlet for the exhaust. And one other component is the oxygen sensor. It monitors the oxygen content of the exhaust so the engine-control computer can adjust the fuel-to-air mix to keep the car running right.

We hope this hasn’t been too ‘exhausting’ of a discussion, but these things impact everything from life and death safety due to exhaust leaks, to just fine-tuning the sound of your ride. And talk with your service advisor at Gustafson Brothers if you feel you need any of these items inspected on your vehicle, because a quick look can sure save a lot of pain down the road.

Auto Tips Videos provided for Gustafson Brothers by AutoNetTV

Share
Posted in Exhaust | Leave a comment

Commitment to Make Your sedan Last At Gustafson Brothers

Posted on February 1, 2012 by gbroshb

For advice on how to make your sedan last longer, visit us at Gustafson Brothers
19161 Gothard Street
Huntington Beach, California 92648
7148475600

These days many people in the Huntington Beach area are really committed to making their cars last a long time. First thing: you’ve got to start with what you’ve got. It’d be ideal if people started with a brand new car, never missed a scheduled service item, paid attention to the severe service maintenance schedule and had regular inspections. But if you’ve had the vehicle for a while, or bought it used, its maintenance history is what it is; and that’s where you start.

Go through the maintenance schedule for your sedan and see what’s been done and when. Have your Huntington Beach service advisor at Gustafson Brothers do an inspection and come up with a list of stuff that needs to be done. Review the list and prioritize the work, talk about budget and make a plan to get caught up.

Making a plan is so important. Suppose you go in for an oil change and learn you need your cooling system serviced, a transmission service and are coming up on a timing belt replacement in the next 5,000 miles. You might be pretty overwhelmed.

To make it even more stressful, these are all very important systems that are expensive to repair if there’s a failure. In consultation with your Huntington Beach service advisor, you might decide to take care of the transmission on this visit, set an appointment for the cooling system service next month and get an estimate for the timing belt replacement so you’ll be prepared for it in a few months.

Having a plan for taking care of these important services will set your mind at ease.

Share
Posted in Maintenance | Leave a comment